Save this manual for future reference.For more information, visit www.desatech.comWARNING: If the information in this manual is not fol-lowed exactly,
www.desatech.com111245-01B103. Remove screws that attach fireplace floor as-sembly to fireplace. Open lower louver door. Carefully lift up fireplace floo
www.desatech.com111245-01B 11INSTALLATIONContinued Note: If you choose to relocate the wall switch assembly, do so before final installation in
www.desatech.com111245-01B124 3/4"3 3/4"3/8"3/16"3/4"3/8"Diameter2 Holes8. Remove paper template from wall. 9. Drill 3
www.desatech.com111245-01B 1313. Position wall switch assembly vertically over opening with decal lettering upright. Make sure wires freely pa
www.desatech.com111245-01B149. Check to make sure that all electrical cords are completely clear of the blower wheel and that there are no ot
www.desatech.com111245-01B 15INSTALLING THERMOSTATIC BLOWER ACCESSORY NOTICE: Shut off gas supply and disconnect heater from gas supply if insta
www.desatech.com111245-01B16INSTALLATIONContinued WARNING: Failure to connect all wires properly as indicated may cause electrical short circuit
www.desatech.com111245-01B 1716. Reattach fireplace floor assembly with screws removed in step 3 of Removing Fire-place Screen and Floor Asse
www.desatech.com111245-01B18 CAUTION: Use only new, black iron or steel pipe. Inter-nally-tinned copper tubing may be used in certain areas.
www.desatech.com111245-01B 193. Attach the flexible gas line to gas supply (see Figure 26). Check tightness of flexible gas line attached to gas
www.desatech.com111245-01B2WARNING: Improper installation, adjustment, altera-tion, service or maintenance can cause injury or prop-erty damage. R
www.desatech.com111245-01B20PRESSURE TESTING FIREPLACE GAS CONNECTIONS1. Open equipment shutoff valve (see Figure 27, page 19).2. Open main gas valv
www.desatech.com111245-01B 215. Route flexible gas line through access hole in hearth base. 6. Center cabinet mantel on hearth base (see Figure 31).
www.desatech.com111245-01B223. If not already completed, install gas piping to fireplace location. This installation includes an approved flexible gas
www.desatech.com111245-01B 23Figure 37 - Minimum Mantel Clearances for Built-In InstallationSuppliedFireboxHoodMust BeUsed atAll TimesWire-meshScreenF
www.desatech.com111245-01B24INSTALLING LOGS WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts
www.desatech.com111245-01B 25Figure 44 - Installing Crossover Logs (#4 & #5) [CGEFP Logs Shown]PinsCrossover Log (#5)Crossover Log (#4)INSTALLING
www.desatech.com111245-01B26NORMAL LIGHTING INSTRUCTIONS WARNING: You must oper-ate this heater with the fireplace screen in place. Make sure fire-place
www.desatech.com111245-01B 27 Note: You may be running this heater for the first time after connecting to gas supply or at the start of your heat
www.desatech.com111245-01B28OPERATING FIREPLACEContinuedTO TURN OFF GAS TO APPLIANCEShutting Off Heater When Manually LitSet manual ignition bypass sw
www.desatech.com111245-01B 29CLEANING AND MAINTENANCE WARNING: Turn off fireplace and let cool before cleaning. CAUTION: You must keep control are
www.desatech.com111245-01B 3SAFETY INFORMATION WARNING: This product con-tains and/or generates chemicals known to the state of California to cause ca
www.desatech.com111245-01B30TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and
www.desatech.com111245-01B 31OBSERVED PROBLEMSlight smoke or odor during initial operationMoisture/condensation noticed on windowsHeater produces a w
www.desatech.com111245-01B32TROUBLESHOOTINGContinued WARNING: If you smell gas• Shut off gas supply.• Do not try to light any appliance.• Do not to
www.desatech.com111245-01B 33OBSERVED PROBLEMGas odor during combustionDark residue on logs or inside of fireplaceNote: After removing all causes
www.desatech.com111245-01B34132442432544401432311211842133962827 714164647331519382934212220363710183035232617941455ILLUSTRATED PARTS BREAKDOWNREMOTE
www.desatech.com111245-01B 35PARTS LISTREMOTE CONTROL LOG BASE ASSEMBLYThis list contains replaceable parts used in your fireplace. When ordering parts
www.desatech.com111245-01B36132442432544401432311211842133962827 714164647331519382934212220363710183035232617941455ILLUSTRATED PARTS BREAKDOWNREMOTE
www.desatech.com111245-01B 37PARTS LISTREMOTE CONTROL LOG BASE ASSEMBLYThis list contains replaceable parts used in your fireplace. When ordering parts
www.desatech.com111245-01B38ILLUSTRATED PARTS BREAKDOWNFIREBOX MODELS CGEFP33PRB, CGEFP33NRB, EFP33PRB AND EFP33NRB12341016811141414671214141351499195
www.desatech.com111245-01B 39PARTS LISTFIREBOX MODELS CGEFP33PRB, CGEFP33NRB, EFP33PRB AND EFP33NRBThis list contains replaceable parts used in your fi
www.desatech.com111245-01B41. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible fo
www.desatech.com111245-01B40ACCESSORIESPurchase these fireplace accessories from your local dealer or Parts Central (see page 43). If they can not
www.desatech.com111245-01B 41LOPILOTOFFHIACCESSORIESContinuedCORNER MANTEL AND BASE ACCESSORY WITH FIREPLACE PERIMETER TRIM (Not Shown)CMA303 Series
www.desatech.com111245-01B42WIRING DIAGRAMNote: For proper operation, the wires must be connected exactly as shown in wiring diagram. See pages 35 or
www.desatech.com111245-01B 43TEMPLATES4 3/4"4 3/4"3 3/4"3/8"3 3/4"3/8"3/16"3/4" 3/4"3/8" Diameter2 H
www.desatech.com111245-01B44THIS PAGE INTENTIONALLY LEFT BLANK
www.desatech.com111245-01B 45PARTS CENTRALThese Parts Centrals are privately owned businesses. They have agreed to support our customerʼs needs by pro
www.desatech.com111245-01B46__________________________________________________________________________________________________________________________
www.desatech.com111245-01B 47NOTES____________________________________________________________________________________________________________________
2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004www.desatech.com111245-01Rev. B09/04NOT A UPC111245 01
www.desatech.com111245-01B 5LOCAL CODESInstall and use fireplace with care. Follow all local codes. In the absence of local codes, use the lat-est edit
www.desatech.com111245-01B6AIR FOR COMBUSTION AND VENTILATION WARNING: This heater shall not be installed in a confined space or unusually tigh
www.desatech.com111245-01B 7AIR FOR COMBUSTION AND VENTILATIONContinued1. Determine the volume of the space (length x width x height). Length
www.desatech.com111245-01B8Ventilation Air From OutdoorsProvide extra fresh air by using ventilation grills or ducts. You must provide two permanent o
www.desatech.com111245-01B 9 WARNING: This appliance is equipped for (natural or pro-pane/LP) gas. Field conversion is not permitted.ELECTRICAL HOO
Comments to this Manuals