Desa CGP10R User Manual

INFRARED VENT-FREE PROPANE/LP GAS HEATEROWNER’S OPERATION AND INSTALLATION MANUALModel: CGP10R®Save this manual for future reference.WARNING: If the i

101018662. Mark two mounting screw locations on wall (see Figure 5).INSTALLING HEATER TO WALLMarking Screw Locations1. Determine where you will locate

11101866Installing Two Mounting ScrewsNote: Wall anchors and mounting screws are in hardware package. The hardwarepackage is provided with heater.Atta

12101866Placing Heater On Mounting Screws1. Locate two keyhole slots on back panel of heater (see Figure 9).2. Place large openings of slots over scre

13101866CONNECTINGTO GASSUPPLYNOTICEA qualified service person must connect heater to gas supply.Follow all local codes.The installer must supply an e

14101866IMPORTANT: Hold pressure regulator with wrench when connecting it to gaspiping and/or fittings.Figure 13 - Gas Connection* An A.G.A. design

151018663. Pressurize supply piping system by either using compressed air oropening propane/LP supply tank valve.4. Check all joints of gas supply pip

16101866OPERATINGHEATERFOR YOUR SAFETY READ BEFORE LIGHTINGLIGHTING INSTRUCTIONS1. STOP! Read the safety information above.2. Make sure manual shutoff

171018664. Wait five (5) minutes to clear out any gas. Then smell for gas, includingnear the floor. If you then smell gas, STOP! Follow “B” in the saf

18101866TO SELECT HEATING LEVELFigure 18 - Burner Patterns1. Slightly press in control knob and turn counterclockwise C-clockwise to theLOW or HIGH po

19101866INSPECTINGBURNERGRH/OV 007GOOD PILOT/LPThermocoupleCheck pilot flame pattern and burner flame pattern often.PILOT FLAME PATTERNFigure 19 shows

2101866CONTENTSSECTION PAGESafety Information ... 2Product Identification ...

20101866If burner flame pattern is incorrect, as shown in Figure 22• turn heater off (see To Turn Off Gas to Appliance, page 19)• see Troubleshooting,

21101866CLEANINGANDMAINTENANCEWARNING ICON G 001 WARNINGTurn off heater and let cool before cleaning.ContinuedWARNING ICON G 001 CAUTIONYou must keep

22101866REMEDY1. Turn on gas supply oropen manual shutoffvalve2. Turn control knob toPILOT position3. Press in control knobwhile in PILOT posi-tion4.

23101866REMEDY1. Clean burner orifice(s)(see Cleaning andMaintenance, page 21)or replace burnerorifice(s)2. Replace burner orifice(s)3. Contact local

24101866TROUBLE-SHOOTINGContinuedTECHNICALSERVICEYou may have further questions about installation, operation, or troubleshooting.If so, contact DESA

25101866Btu (Variable) 5,500/10,000Type Gas Propane/LP OnlyIgnition PiezoPressure Regulator Setting 8" W.C.Inlet Gas Pressure (inches of water)Ma

26101866PARTSCENTRALSThese Parts Centrals are privately owned businesses. They have agreed to supportour customer’s needs by providing original replac

27101866PARTS LISTCGP10RThis list contains replaceable parts used in your heater. When ordering parts, followthe instructions listed under Replacement

KEEP THIS WARRANTYWARRANTY INFORMATIONAlways specify model and serial numbers when communicating with the factory.We reserve the right to amend these

3101866SAFETYINFORMATIONContinuedWARNING ICON G 001 WARNINGS ContinuedWARNING: Any change to this heater or its controls can be dangerous.1. This appl

4101866PRODUCTIDENTIFICATIONPRODUCTFEATURESSafety DeviceThis heater has a pilot with an Oxygen Depletion Sensor Shutoff System (ODS).The ODS/pilot is

5101866AIR FORCOMBUSTIONANDVENTILATIONWARNING ICON G 001 WARNINGThis heater shall not be installed in a confined space unlessprovisions are provided f

6101866AIR FORCOMBUSTIONANDVENTILATIONContinuedDETERMINING AIR FLOW FOR HEATER LOCATIONDetermining if You Have a Confined or Unconfined SpaceUse this

7101866AIR FORCOMBUSTIONANDVENTILATIONContinuedFigure 2 - Ventilation Air from Inside BuildingOr Remove Door into Adjoining Room, Option 3Ventilation

8101866AIR FORCOMBUSTIONANDVENTILATIONContinuedFigure 3 - Ventilation Air from OutdoorsOutletAirVentilatedAttic OutletAirInletAirInlet AirVentilated C

9101866INSTALLING TOWALLNOTICEA qualified service person must install heater. Follow all local codes.CHECK GAS TYPEUse only propane/LP gas. If your ga